mk5 Hilux 2KD - (Injector?) Rattle?

Turbo, Manifolds, Exhaust, Intercooler, Internals etc

mk5 Hilux 2KD - (Injector?) Rattle?

Postby Jake123 on Wed, 15 May 2019 2:43 +0000

Hey guys,

Bit of advice if you could.

I have a 2005 hilux, 2.5 d4d 2KD.
Under light throttle, just about maintaining speed it rattles really quite loudly.
The noise goes like a switch if you accelerate or let off.

Worse in colder weather and in warmer weather the noise quietens down a LOT.

Ive had a new fuel filter, new suction control valve and run some injector cleaner through.
Injector feedback values all good, well withing +/-3.
Done a reset and initialization of the EFI, Nothing made any change...

Its driving me mad!

I read a lot about a 'normal' EGR or Injector rattle but this seems very loud.
You can hear it over the radio but its only at that certain throttle position and a light engine load, starts/drives/stops fine otherwise.

Any suggestions?
Surely they havent all done this since new...
Jake123
 
Posts: 2
Joined: Thu, 02 May 2019 6:26 +0000
Location: United Kingdom


 

Re: mk5 Hilux 2KD - (Injector?) Rattle?

Postby DeadlyBeast on Wed, 15 May 2019 5:21 +0000

Hi Jake
Limited info on the 2kd here however you can type the below into a search engine or the search here box top left of screen: Cold rattle site:www.newhilux.net

It's normal on the 1kd

You could try cleaning the MAF and MAP if the old 2kd have them?

Probably can't do a pilot learn on a 2005

Some say if it's still rattling after new injectors and SCV then it's the swirl control

Can try adding 2 stroke oil in the fuel - there's a thread on that. I tried it - didn't make much difference
If you're going through hell, keep going.
________________________
2007 SR5 D4D Auto
2014 SR D4D Auto
Build Thread
User avatar
DeadlyBeast
Moderator
 
Posts: 1690
Joined: Sat, 26 May 2012 7:42 +0000
Location: Top End

Re: mk5 Hilux 2KD - (Injector?) Rattle?

Postby Jake123 on Wed, 15 May 2019 10:23 +0000

Thanks for the reply.

From videos it sounds similair ish to the 1kd engines that exhibit the light machine gun type rattle!
But as mentioned only at that one specific throttle position.

2kd doesn't have swirl control valves and still makes the noise so although I've read that in a few places I don't buy i...

I'll try a MAF clean.

It is slightly louder when cold but certainly does not go once warm.
Jake123
 
Posts: 2
Joined: Thu, 02 May 2019 6:26 +0000
Location: United Kingdom


Return to Engines

Who is online

Users browsing this forum: No registered users and 1 guest