NewHilux.net

by **imthebundybear** on Fri, 07 Mar 2014 6:15 +0000

hey guys im only new to this forum but i have a big problem and i dont understand why...

in first gear idle to about 2000 rpm i have power and accelation but after that she just struggles
the rest of the gears she just has minimal power and accelation barly reaching 3000 Rpm and struggles to reach 80kph

i talked to the toyota service person and he is saying the EGR needs to be removed and acid dipped???

please help anything will help

cheers daniel

by **miles n miles a road** on Fri, 07 Mar 2014 6:37 +0000

have the maf sencer and map sencer ever been cleaned...hows the fuel filter and air filter as well..might be worth checking these things first..hope this helps

by **imthebundybear** on Fri, 07 Mar 2014 7:01 +0000

miles n miles a road wrote:have the maf sencer and map sencer ever been cleaned...hows the fuel filter and air filter as well..might be worth checking these things first..hope this helps

Thanks for the reply buddy
??? What is the MAF and MAP senser and where are they located
Also I only just replaced the diesel filter only end of last year

By the way I don't hear the turbo spooling up in the 2nd and up gears

by **miles n miles a road** on Fri, 07 Mar 2014 7:04 +0000

viewtopic.php?f=13&t=20711

by **miles n miles a road** on Fri, 07 Mar 2014 7:11 +0000

viewtopic.php?f=13&t=20254

by **imthebundybear** on Fri, 07 Mar 2014 7:13 +0000

Cheers mate I'll do the MAP tomorrow I have already done the MAF sensor and thanks again

by **miles n miles a road** on Fri, 07 Mar 2014 7:13 +0000

im only a learner an it could be anything but that's where id start

by **mitch_893** on Fri, 07 Mar 2014 7:26 +0000

My guess would be that your going to be forking out some cash for a turbo.

by **mattwhite** on Fri, 07 Mar 2014 7:33 +0000

No fault codes? Id suspect Mitch will be on the money. Either a turbo or a turbo control problem. Really needs some proper diagnosis before replacing anything but. Good luck.

by **imthebundybear** on Fri, 07 Mar 2014 7:39 +0000

I hear the turbo spool in the first gear as I said about the first gear but then the other gears I hear nothing

by **mattwhite** on Fri, 07 Mar 2014 7:49 +0000

There's a difference between the turbo spinning and actually boosting under load. Your egr prol is dirty but didn't suddenly block and it sounds to be pretty serious for a serious problem. We're all just throwing ideas out there man trying to help?
Is there any fault codes?

by **imthebundybear** on Fri, 07 Mar 2014 8:00 +0000

Na not sure about fault codes my engine light has been on for a long time (other reasons) and thank you I do understand, I'm not trying to have a go at anyone or a smarta**I didn't mean anything bad, just letting you's know about it (trying to be discriptive) I do muchly appreciate the help

I didn't hear anything happen with the turbo ( clunking, grinding) nothing like that at all I just woke up one morning to go to work and it just seemed to run like a peice of s***

by **mitch_893** on Fri, 07 Mar 2014 9:31 +0000

Yeah i think usually the variable vane actuator on the turbo stops working, causing it to jam up in 'low rpm mode'. Hence why your hearing it in first gear.

by **imthebundybear** on Sat, 08 Mar 2014 1:04 +0000

?? Where is that and is there a way to test it?

by **mattwhite** on Sat, 08 Mar 2014 4:03 +0000

That's the little electric motor on the top of the turbo. It's also what causes the buzzing noise when you turn the ignition on. My suggestion would be get the codes out and see what they are and fix what you know is wrong before you go chasing more faults.

by **imthebundybear** on Sat, 08 Mar 2014 4:12 +0000

Hey buddy, I have already pulled that motor off and supplied it with power (outside the vehicle) it seemed to work fine, is there a way to get the codes without a computer I have done it on a vectra but can't seem to find anything on a hilux??

by **Swinder** on Sat, 08 Mar 2014 4:56 +0000

I'm very interested to find out what it could be.
Have you checked all your vacuum hoses are connected :?:

by **imthebundybear** on Sat, 08 Mar 2014 5:04 +0000

Yeh me too and also as far as I know all my vacuum hoses are still connected, like I said I woke up Monday morning and she started doing this

I'm lost

by **deffer64** on Sat, 08 Mar 2014 7:08 +0000

Hi I had a similar problem turned out to be a vacuum line under the left hand side off engine cover at rear it was a split line and was letting it suck air a new piece off hose and fixed mind you I had to buy a metre off hose $8.00 for a piece 100mm long that's life

by **imthebundybear** on Sat, 08 Mar 2014 7:12 +0000

deffer64 wrote:Hi I had a similar problem turned out to be a vacuum line under the left hand side off engine cover at rear it was a split line and was letting it suck air a new piece off hose and fixed mind you I had to buy a metre off hose $8.00 for a piece 100mm long that's life

Hey mate are you able to discribe or take a pic for me so I know which one it is, that would be muchly appreciated

NewHilux.net

06 hilux loss of accelation and power

Re: 06 hilux loss of accelation and power

Re: 06 hilux loss of accelation and power

Re: 06 hilux loss of accelation and power

Re: 06 hilux loss of accelation and power

Re: 06 hilux loss of accelation and power

Re: 06 hilux loss of accelation and power

Re: 06 hilux loss of accelation and power

Re: 06 hilux loss of accelation and power

Re: 06 hilux loss of accelation and power

Re: 06 hilux loss of accelation and power

Re: 06 hilux loss of accelation and power

Re: 06 hilux loss of accelation and power

Re: 06 hilux loss of accelation and power

Re: 06 hilux loss of accelation and power

Re: 06 hilux loss of accelation and power

Re: 06 hilux loss of accelation and power

Re: 06 hilux loss of accelation and power

Re: 06 hilux loss of accelation and power

Re: 06 hilux loss of accelation and power