5 gears Auto gearbox question

Gearboxs, Transfers, Tailshafts, Diffs, axles and CVs

5 gears Auto gearbox question

Postby stefanbalik on Fri, 18 Sep 2020 7:23 +0000

Hi everyone,

I have a problem and i need some help.

I have an Hilux 2009 model, 3.0L D4D, with 5 gears auto gearbox and 170.000kms .
One month ago, the car begins to emit black smoke when i was going at low speeds and accelerate.
The local Toyota said that injectors had a problem.
We check and clear the injectors but again the same smoke.
After that they said that EGR has a problem but they cannot clear it because they don't have time.
So i put a clear blanket in the pipe of EGR until they can clear my EGR.
But when I drive on the highway at a constant speed and 5th in the gearbox, and need to stop abruptly, when I get to stop I understand a very small 'hit' as soon as the engine speed drops to idle. As soon as I start again it does not go up from 4th to 5th.
However, if I turn off the car for 1 second and start again, it immediately works normally.

Τhe local dealership once told me that the ECT wants a change and then that it wants to repair the auto gearbox with a cost of over 3000 €.

if anyone has a similar experience and can help I would appreciate it.

sorry for my English


Regards

Stefanos
User avatar
stefanbalik
 
Posts: 4
Joined: Wed, 23 Jun 2010 7:32 +0000
Location: Hellas


 

Re: 5 gears Auto gearbox question

Postby stefanbalik on Wed, 30 Sep 2020 7:44 +0000

Hi team,

Just for update,

We remove the clear blanket plate and make a hole of 4mm in the center of it and reinstall it.

I didn't have a problem again with the transmission fault from 4th to 5th gear.

In low speed in the begin only i have a little black smoke.

Regards

Stefanos
User avatar
stefanbalik
 
Posts: 4
Joined: Wed, 23 Jun 2010 7:32 +0000
Location: Hellas


Return to Drive Train Components

Who is online

Users browsing this forum: No registered users and 9 guests