hilux cut out
11 posts
• Page 1 of 1
hilux cut out
by Hobbit873 on Tue, 08 Dec 2020 9:09 +0000
i have a 2013 hilux d4d pulling up to a set of lights car just cut out, no warning no surging just straight cut out. car now just cranks and wont fire. checked fuel and primes up good, checked fuses and relays, have no fault codes. tried disconnecting battery for a bit. has 160000km on it. just strange that had no warning leading up to it... anyone have any ideas?
- Hobbit873
- Posts: 22
- Joined: Thu, 20 Feb 2014 9:01 +0000
Re: hilux cut out
by Gipsy on Tue, 08 Dec 2020 9:13 +0000
No lights on the dash? What has been done to the vehicle lately? Filled up with fuel? Service, filter change or any other work? Do you know how to drain the fuel filter? If so, check for water in the fuel. Your manual shows how. When you say checked fuel, what did you check?
Cheers Gipsy 
although I'm sure somebody will challenge that 
even Einstein wasn't certain of his theories.
My 2013 auto D4D DC SR5, prefilter, 3" exhaust and Chip with egt probe, stock SR5 rims with Toyo Open Country AT2 265/65R/17's
although I'm sure somebody will challenge that even Einstein wasn't certain of his theories.My 2013 auto D4D DC SR5, prefilter, 3" exhaust and Chip with egt probe, stock SR5 rims with Toyo Open Country AT2 265/65R/17's
- Gipsy
- Posts: 2147
- Joined: Tue, 07 May 2013 2:00 +0000
- Location: South Coast NSW and all over Oz
Re: hilux cut out
by Hobbit873 on Tue, 08 Dec 2020 9:37 +0000
have all lights are on dash and go out once cranking car over, have drained fuel filter and checked that its pumping out, has same fuel from a week ago, did oil change 2 days ago.
- Hobbit873
- Posts: 22
- Joined: Thu, 20 Feb 2014 9:01 +0000
Re: hilux cut out
by Gipsy on Tue, 08 Dec 2020 9:45 +0000
Did you check for water in the fuel? When you prime the filter does it go hard, is it hard before pumping?
It's unlikely to be electrical because it was running and cut out... Most likely fuel related.
It's unlikely to be electrical because it was running and cut out... Most likely fuel related.
Cheers Gipsy although I'm sure somebody will challenge that even Einstein wasn't certain of his theories.
My 2013 auto D4D DC SR5, prefilter, 3" exhaust and Chip with egt probe, stock SR5 rims with Toyo Open Country AT2 265/65R/17's
although I'm sure somebody will challenge that even Einstein wasn't certain of his theories.My 2013 auto D4D DC SR5, prefilter, 3" exhaust and Chip with egt probe, stock SR5 rims with Toyo Open Country AT2 265/65R/17's
- Gipsy
- Posts: 2147
- Joined: Tue, 07 May 2013 2:00 +0000
- Location: South Coast NSW and all over Oz
Re: hilux cut out
by Hobbit873 on Tue, 08 Dec 2020 10:06 +0000
yes checked for water, yes its hard, going to try see if it has fuel to the injectors tonight. a mates told me possibly suction control valve on the pump?
- Hobbit873
- Posts: 22
- Joined: Thu, 20 Feb 2014 9:01 +0000
Re: hilux cut out
by Gipsy on Tue, 08 Dec 2020 10:17 +0000
Yes scv possible or supply pump (on the engine)
Unfortunately when you disconnected the battery you lost all the pending codes, otherwise you could check for codes. If you have or mate has obd scanner it may show something.
Unfortunately when you disconnected the battery you lost all the pending codes, otherwise you could check for codes. If you have or mate has obd scanner it may show something.
Cheers Gipsy although I'm sure somebody will challenge that even Einstein wasn't certain of his theories.
My 2013 auto D4D DC SR5, prefilter, 3" exhaust and Chip with egt probe, stock SR5 rims with Toyo Open Country AT2 265/65R/17's
although I'm sure somebody will challenge that even Einstein wasn't certain of his theories.My 2013 auto D4D DC SR5, prefilter, 3" exhaust and Chip with egt probe, stock SR5 rims with Toyo Open Country AT2 265/65R/17's
- Gipsy
- Posts: 2147
- Joined: Tue, 07 May 2013 2:00 +0000
- Location: South Coast NSW and all over Oz
Re: hilux cut out
by Hobbit873 on Tue, 08 Dec 2020 10:33 +0000
yeah thats what im thinking about the codes. checked at home with obd scan tool and showed no faults.. when cranking engine light stays on.. but no stored faults
- Hobbit873
- Posts: 22
- Joined: Thu, 20 Feb 2014 9:01 +0000
Re: hilux cut out
by Gipsy on Tue, 08 Dec 2020 11:46 +0000
Unfortunately the codes are only stored after engine starts. That's why I keep my scanner in the vehicle at all times.
Cheers Gipsy although I'm sure somebody will challenge that even Einstein wasn't certain of his theories.
My 2013 auto D4D DC SR5, prefilter, 3" exhaust and Chip with egt probe, stock SR5 rims with Toyo Open Country AT2 265/65R/17's
although I'm sure somebody will challenge that even Einstein wasn't certain of his theories.My 2013 auto D4D DC SR5, prefilter, 3" exhaust and Chip with egt probe, stock SR5 rims with Toyo Open Country AT2 265/65R/17's
- Gipsy
- Posts: 2147
- Joined: Tue, 07 May 2013 2:00 +0000
- Location: South Coast NSW and all over Oz
Re: hilux cut out
by Hobbit873 on Fri, 11 Dec 2020 8:34 +0000
turns out i run out of fuel even though gauge had 1/4 tank. going to check cluster out next
- Hobbit873
- Posts: 22
- Joined: Thu, 20 Feb 2014 9:01 +0000
Re: hilux cut out
by Gipsy on Fri, 11 Dec 2020 8:41 +0000
Hobbit, did you read through this thread? In particular page 2 from cambo.
https://www.newhilux.net/phpbb/viewtopic.php?f=29&t=29318&start=20
https://www.newhilux.net/phpbb/viewtopic.php?f=29&t=29318&start=20
Cheers Gipsy although I'm sure somebody will challenge that even Einstein wasn't certain of his theories.
My 2013 auto D4D DC SR5, prefilter, 3" exhaust and Chip with egt probe, stock SR5 rims with Toyo Open Country AT2 265/65R/17's
although I'm sure somebody will challenge that even Einstein wasn't certain of his theories.My 2013 auto D4D DC SR5, prefilter, 3" exhaust and Chip with egt probe, stock SR5 rims with Toyo Open Country AT2 265/65R/17's
- Gipsy
- Posts: 2147
- Joined: Tue, 07 May 2013 2:00 +0000
- Location: South Coast NSW and all over Oz
Re: hilux cut out
by Hobbit873 on Fri, 11 Dec 2020 2:32 +0000
yeah did have a read after a mate told me about the dash issues. have resolderd today and wait and see if it drops down
- Hobbit873
- Posts: 22
- Joined: Thu, 20 Feb 2014 9:01 +0000
11 posts
• Page 1 of 1
Who is online
Users browsing this forum: No registered users and 9 guests
